Journal of Jilin University(Earth Science Edition) ›› 2021, Vol. 51 ›› Issue (5): 1570-1577.doi: 10.13278/j.cnki.jjuese.20200275

Previous Articles     Next Articles

Reinforcement-Mud-Rock Bonding Test Based on FAST-1 New High Strength Anchoring Agent

Liu Quanwei1, Huang Cheng1, Liu Linsheng1, Ye Shoujie1, Zang Guoqiang2, Gao Wenlong3, Zhang Jin4   

  1. 1. Qingdao Metro Line 6 Co. Ltd., Qingdao 266100, Shandong, China;
    2. Shandong Xurui Environmental Geotechnical Engineering Investigation and Design Co. Ltd., Qingdao 266100, Shandong, China;
    3. Qingdao Branch, SGIDI Engineering Consulting(Group) Co. Ltd., Qingdao 266100, Shandong, China;
    4. School of Civil Engineering, Qingdao University of Technology, Qingdao 266033, Shandong, China
  • Received:2020-11-26 Online:2021-09-26 Published:2021-09-29
  • Supported by:
    Supported by the Youth Fund of National Natural Science Foundation of China (41702320)

Abstract: In order to study the anchoring performance and optimal anchoring length of the FAST-1 new high strength anchoring agent, the bonding performance of the reinforced slurry rock system based on the FAST-1 new high strength anchoring agent was studied from many aspects through the ultimate pull-out test under continuous load. The continuous curve model with good fitting effect was selected to calculate the relative slip, which can effectively reflect the bonding properties of different interfaces, and the effective calculation method of reinforcement slurry length was optimized. It is found that when the water material ratio is in a certain range (0.22-0.31), and it affectes the failure mode of the anchor structure in the drawing process. The smaller the water material ratio, the greater the bond strength, but the worse the fluidity; The bonding performance of the anchoring agent to the rock stratum is greater than that of the anchor cable; Increasing the contact area between the anchor cable and the slurry consolidation body can effectively improve the anchoring performance. It is concluded that the new anchoring agent has the characteristics of high early strength, and the design strength can be reached with 24 h; The anchorage length is related to the length of the anchor body. It is suggested that the anchorage length is 10.0d-15.0d(d is the diameter of the anchor cable).

Key words: anchoring agent, bonding strength, bonding displacement, anchorage length

CLC Number: 

  • U455
[1] 孙超, 许成杰. 基坑开挖对周边环境的影响[J]. 吉林大学学报(地球科学版), 2019, 49(6):1698-1705. Sun Chao, Xu Chengjie. Influence of Excavation of a Deep Excavation on the Surrounding Environment[J]. Journal of Jilin University (Earth Science Edition), 2019, 49(6):1698-1705.
[2] 郎秋玲, 王伟, 高成梁. 基于组合权重与灰色关联度分析法的地铁深基坑开挖稳定性评价[J]. 吉林大学学报(地球科学版), 2020, 50(6):1823-1832. Lang Qiuling, Wang Wei, Gao Chengliang. Stability Evaluation of Deep Foundation Pit of Metro Based on Grey Correlation Analysis with Combined Weights[J]. Journal of Jilin University (Earth Science Edition), 2020, 50(6):1823-1832.
[3] 刘少伟, 王伟, 付孟雄, 等.螺纹钢锚杆搅拌锚固剂力学特征分析与端部形态优化实验[J]. 中国矿业大学学报, 2020, 49(3):419-427. Liu Shaowei, Wang Wei, Fu Mengxiong, et al. Mechanical Characteristics Analysis and End Shape Optimization Experiment of Stirring Anchoring Agent for Rebar Bolts[J]. Journal of China University of Mining and Technology, 2020, 49(3):419-427.
[4] 白俊杰, 薛小龙.锚索现场张拉预紧力损失试验研究[J]. 煤炭科技, 2020, 41(3):50-51, 63. Bai Junjie, Xue Xiaolong. Experimental Study on Loss of Anchor Cable Pretension in Situ[J]. Coal Science and Technology, 2020, 41(3):50-51, 63.
[5] 王大强, 刘晓丽, 汪辉, 等. 纤维筋与高强纤维混凝土的黏结性能[J]. 低温建筑技术, 2011(6):14-16. Wang Daqiang, Liu Xiaoli, Wang Hui, et al. Bond Performance Between Fiber Reinforced Concrete and High-Strength Fiber Reinforced Concrete[J]. Cryogenic Building Technology, 2011(6):14-16.
[6] 刘鸣, 宋建平, 刘军, 等. 膨胀土水泥改性施工均匀性试验研究[J]. 岩土工程学报, 2017, 39(增刊1):59-63. Liu Ming, Song Jianping, Liu Jun, et al. Experimental Study on Construction Uniformity of Expansive Soil Cement Modification[J]. Journal of Geotechnical Engineering, 2017, 39(Sup.1):59-63.
[7] 梁新民, 张永达, 胡光球, 等.全长锚固预应力树脂锚杆受力特性分析及应用[J]. 黄金, 2015, 36(4):38-42. Liang Xinmin, Zhang Yongda, Hu Guangqiu, et al. Analysis and Application of Stress Characteristics of Full-Length Anchored Prestressed Resin Bolt[J]. Gold, 2015, 36(4):38-42.
[8] 吴爱祥, 李莉, 王贻明, 等.快慢凝预应力树脂锚杆与围岩相互作用的力学特征[J]. 北京科技大学学报, 2012, 34(4):363-367. Wu Aixiang, Li Li, Wang Yiming, et al. Mechanical Characteristics of the Interaction Between Fast and Slow Solidifying Pre-Stressed Resin Bolt and Surrounding Rock[J]. Journal of University of Science and Technology Beijing, 2012, 34(4):363-367.
[9] 陈梅.浅谈树脂锚固剂生产工艺及技术改造[J]. 科技创新导报, 2019, 16(12):111-112. Chen Mei. Discussion on Production Process and Technical Transformation of Resin Anchorage Agent[J]. Science and Technology Innovation Guide, 2019, 16(12):111-112.
[10] Ganesh R. Vertical Uplift Resistance of Close-Spaced Shallow Rectangular Group Anchor Plates Embedded in Sand[J]. Marine Georesources & Geotechnology, 2020, 38(9):1070-1081.
[11] Anamitra R, Paramita B. Diameter Effect on Uplift Capacity of Horizontal Circular Anchor Embedded in Sand[J]. International Journal of Geotechnical Engineering, 2020, 14(7):779-792.
[12] 崔棚, 戴梦希, 丁铸, 等.磷酸镁水泥砂浆与混凝土的锚固黏结性能研究[J]. 中国建材科技, 2020, 29(2):19-23. Cui Peng, Dai Mengxi, Ding Zhu, et al. Research on Anchorage Bond Performance of Magnesium Phosphate Cement Mortar and Concrete[J]. China Building Materials Science and Technology, 2020, 29(2):19-23.
[13] 青岛理工大学. 高强快速锚固剂及其浆液的制备方法, ZL201810739147.0[P]. 2019-12-17. Qingdao University of Technology. High-Strength Fast Anchoring Agent and Preparation Method of Its Slurry, ZL201810739147.0[P]. 2019-12-17.
[14] 高丹盈, 朱海堂, 谢晶晶.纤维增强塑料筋混凝土黏结滑移本构模型[J]. 工业建筑, 2003, 33(7):41-43, 82. Gao Danying, Zhu Haitang, Xie Jingjing. Bond Slip Constitutive Model of Fiber Reinforced Plastic Reinforced Concrete[J]. Industrial Construction, 2003, 33(7):41-43, 82.
[15] 混凝土结构设计规范:GB 50010-2010[S].北京:中国建筑工业出版社, 2012. Code for Design of Concrete Structures:GB 50010-2010[S]. Beijing:China Construction Industry Press, 2012.
[16] Building Code Requirements for Structural Concrete and Commentary:ACI 318M-05[S].[S.l.]:American Concrete Institute, 2004.
[17] 钢筋套筒灌浆连接应用技术规程:JGJ 355-2015[S]. 北京:中国建筑工业出版社, 2012. Technical Specification for Application of Reinforced Sleeve Grouting Connection:JGJ 355-2015[S]. Beijing:China Construction Industry Press, 2012.
[1] Diao Guojun , He Xin. Key Technology of Local Underground and Enlarged Excavation Construction of Subway Open-Cut Station Underpassing Existing Buildings [J]. Journal of Jilin University(Earth Science Edition), 2025, 55(2): 536-549.
[2] Wang Wei, Wang Xing, Zhou Xun, Wei Shengda. Cluster Analysis of Influencing Factors of Surface Subsidence in Shield Interval of Sandy Gravel Stratum#br# [J]. Journal of Jilin University(Earth Science Edition), 2024, 54(1): 219-230.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] LIU Jian-feng, CHI Xiao-guo, ZHOU Yan, WANG Tie-fu,JIN Wei, ZHOU Jian-bo, DONG Chun-yan, LI Guang-rong. Rb-Sr Isotopic Dating of the Jinlin Pluton by Whole Rock-Hornblende Method in the Northeast Xiao Hinggan Mountains[J]. J4, 2005, 35(06): 690 -0693 .
[2] HUANG Guan-xing, SUN Ji-chao, ZHANG Ying, LIU Jing-tao, ZHANG Yu-xi, JING Ji-hong. Content and Relationship of Heavy Metals in Groundwater of Sewage Irrigation Area in Pearl River Delta[J]. J4, 2011, 41(1): 228 -234 .
[3] XIAO Chang-lai,LIANG Xiu-juan, CUI Jian-ming, LAN Ying-ying,ZHANG Jun, LI Shu-lan, LIANG Rui-qi, ZHENG Ce. Whole Curve Matching Method for Aquifer Parameters Determination[J]. J4, 2005, 35(06): 751 -0755 .
[4] GUO Zhen-hua, WANG Pu-jun, YIN Chang-hai, HUANG Yu-long. Relationship Between Lithofacies and Logging Facies of the Volcanic Reservoir Rocks in Songliao Basin[J]. J4, 2006, 36(02): 207 -0214 .
[5] SUN Yong-he, FU Xiao-fei, LV Yan-fang, FU Guang, YAN Dong. Suction Role of Seismic Pumping and Physical Simulation on Hydrocarbon Migration and Accumulation[J]. J4, 2007, 37(1): 98 -0104 .
[6] XIE Zhong-lei, CHEN Zhuo,SUN Wen-tian, YIN Bo. Content of Fluoride in Tea Leaves and Distribution of Fluoride in Soils from Different Tea Gardens[J]. J4, 2008, 38(2): 293 -0298 .
[7] JIA Jun-tao, WANG Pu-jun, SHAO Rui,CHENG Ri-hui, ZHANG Bin, HOU Jing-tao, LI Jin-long, BIAN Wei-hua. Stratigraphical Sequence and Regional Correlation of Yingcheng Formation in the Southeast of Songliao Basin[J]. J4, 2007, 37(6): 1110 -1123 .
[8] KANG Li-ming,REN Zhan-li. Study on Multi-Parameters Discrimination Method for Flow Units-Taking W93 Wellblock in Ordos Basin as An Example[J]. J4, 2008, 38(5): 749 -0756 .
[9] XUE Yong-chao, CHENG Lin-song. The Diagenetic Reservoir Facies of Chang 8 Reservoir in Baibao Oilfield[J]. J4, 2011, 41(2): 365 -371 .
[10] JIANG Ji-yi, ZHANG Yu-dong, GU Hong-biao, ZUO Lan-li. Study on the Evaluation Model of Groundwater Environment Evolution Pattern Based on Grey Correlation Entropy[J]. J4, 2009, 39(6): 1111 -1116 .