Journal of Jilin University(Engineering and Technology Edition) ›› 2023, Vol. 53 ›› Issue (4): 1094-1104.doi: 10.13229/j.cnki.jdxbgxb.20210849

Previous Articles    

Experiment on cracks in reinforced concrete beams based on digital image correlation technology

Er-gang XIONG(),Zhong-wen GONG,Jia-ming LUO,Tuan-jie FAN   

  1. School of Civil Engineering，Chang′an University，Xi′an 710061，China
  • Received:2021-08-30 Online:2023-04-01 Published:2023-04-20

RICH HTML

 1   

PDF (PC)

127

Abstract:

In order to investigate the influence of shear span ratio on the initiation and propagation of cracks in reinforced concrete beam， according to Code for Design of Concrete Structures， a group of reinforced concrete beams with shear span ratios of 4.0， 3.0， 2.5 and 2.0 were designed. Through the digital image correlation （Digital image correlation， DIC） technology， the whole process of crack initiation and evolution was captured for the reinforced concrete beam components under the monotonic loading. The distribution and width of the cracks in RC beams were reproduced in different loading levels. The test results are compared with the calculated values by the use of major design codes. The results show that the DIC technology is a realistic test observation method； the distribution of cracks has a very important relationship with the shear span ratio， and the larger cracks of the test beam are mainly distributed in the pure bending section. At the same time， the position and width of the cracks are almost evenly distributed within the pure bending section. This is basically consistent with the crack calculation formula given in major design codes.

Key words: structural engineering, DIC technology, reinforced concrete beam, crack, shear-span ratio

CLC Number: 

  • TU375.1

Fig.1

Beam reinforcement diagram"

Fig.2

DIC diagram"

Fig.3

Loading device diagram"

Fig.4

Comparison of deflection measurements undervarious loads"

Fig.5

Load-deflection curve comparison"

Fig.6

Crack development observed by surface strain"

Table 1

First crack， length and number cracks measured with DIC technology"

试件 编号开裂荷载/kN裂缝长度1/mm裂缝数量2破坏形式
A55391.5625弯曲破坏
B55333.7524弯曲破坏
C85369.6927弯曲破坏
D90348.8021弯曲破坏

Fig.7

Schematic diagram of crack width extraction"

Fig.8

Srack position and width information"

Fig.9

Relationship between test beam bending momentand crack width"

Table 2

Experimental and theoretical moments at the first cracking"

试件试验值/kN规范计算值/kN试验值/理论值
ACIEurocode2CSAGBACIEurocode2CSAGB
A5539.6134.5819.1733.521.381.592.861.64
B5552.8246.1025.5644.701.041.192.151.23
C8563.3955.3230.6753.641.341.532.771.58
D9079.2369.1638.3467.051.131.302.341.34

Table 3

Comparison of experimental and theoretical crack spacing"

试件试验值/mm规范计算值/mm试验值/理论值
EC2?92EC2?04MC?90GB?10EC2?92EC2?04MC?90GB?10
A151.8084.60164.2396.13128.911.790.921.571.17
B178.752.111.081.851.38
C193.372.281.172.011.50
D155.691.840.941.611.20

Fig.10

Crack width： comparison of test results with code′s models"

1 Shih M H, Sung W P. Application of digital image correlation method for analyzing crack variation of reinforced concrete beams[J]. Sadhana, 2013, 38(4): 723-741.
2 Fayyad T M, Lees J M. Experimental investigation of crack propagation and crack branching in lightly reinforced concrete beams using digital image correlation[J]. Engineering Fracture Mechanics, 2017, 182: 487-505.
3 赵亚军,窦远明,崔立杰. 基于DIC方法研究钢筋混凝土裂缝扩展规律分析[J]. 混凝土,2017, 38(5): 1-4.
Zhao Ya-jun, Dou Yuan-ming, Cui Li-jie. Investigation of the reinforced concrete crack propagation law on the DIC method[J]. Concrete, 2017, 38(5): 1-4.
4 Golewski G L. Measurement of fracture mechanics parameters of concrete containing fly ash thanks to use of Digital Image Correlation (DIC) method[J]. Measurement, 2019, 135: 96-105.
5 Li D, Huang P, Chen Z, et al. Experimental study on fracture and fatigue crack propagation processes in concrete based on DIC technology[J]. Engineering Fracture Mechanics, 2020, 235: No.107166.
6 范团结. 基于DIC技术RC梁裂缝的试验及数值模拟研究[D]. 西安:长安大学建筑工程学院, 2020.
Fan Tuan-jie. Experimental and numerical simulation of cracks in RC beams based on DIC technology[D]. Xi'an: School of Civil Engineering and Architecture, Chang'an University, 2020.
7 徐少波,顾国庆,于小娟,等. 基于数字图像相关的力学测试系统设计与应用[J]. 盐城工学院学报: 自然科学版,2018, 31(4): 69-72.
Xu Shao-bo, Gu Guo-qing, Yu Xiao-juan, et al. Design and application of mechanical testing system based on digital image correlation[J]. Journal of Yancheng Institute of Technology(Natural Science Edition), 2018, 31(4): 69-72.
8 Yamaguchi I, Yokota M, Ida T. Monitoring of paint drying process by digital speckle correlation[J]. Optical review, 2007, 14(6): 362-364.
9 Peters W H, Ranson W F. Digital imaging techniques in experimental stress analysis[J]. Optical Engineering, 1981, 21(3): 427-431.
10 崔新男,汪旭光,王尹军,等. 爆炸加载下混凝土表面的裂纹扩展[J]. 爆炸与冲击,2020, 40(5): 25-35.
Cui Xin-nan, Wang Xu-guang, Wang Yin-jun, et al. External crack propagation of concrete surface under explosive loading[J]. Explosion and Shock Waves, 2020, 40(5): 25-35.
11 Fayyad T M, Lees J M. Application of digital image correlation to reinforced concrete fracture[J]. Procedia Materials Science, 2014, 3: 1585-1590.
12 Alam S Y, Loukil A, Grondin F, et al. Use of the digital image correlation and acoustic emission technique to study the effect of structural size on cracking of reinforced concrete[J]. Engineering Fracture Mechanics, 2015, 143: 17-31.
13 . 混凝土结构设计规范 [S].
14 ACI 318―95. Building code requirement for structural concrete and commentary [S].
15 EN 1992-1-1 : 2004. Eurocode 2: design for concrete structures-part 1:general rules and rules for buildings [S].
16 CSA A23.3-04. Design of concrete structures [S].
17 EN 1992-1-1 : 1992. Eurocode 2: design for concrete structures-part 1:general rules and rules for buildings [S].
18 MC90 C. Comite euro-international du beton-federation international de la pre-contrainte (CEB-FIP), model code 90 for concrete structures [S].
19 . Structural use of concrete [S].
20 TC 162 -TDF R. Test and design methods for steel fibre reinforced concrete[J]. Materials and Structures, 2003, 36(262): 560-567.
[1] Xiao-dong WANG,Ning-jing LI,Qiang LI. Experimental on crushing of concrete beams by high⁃voltage pulse discharge [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(2): 496-504.
[2] Ya-chuan KUANG,Li-bin CHEN,Chao-ju LI,Yu-hao HE. Analysis of mechanical properties of stud shear connectors [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(2): 538-546.
[3] Yun-peng CHU,Xin-hui SUN,Ming LI,Yong YAO,Han-jie HUANG. Wind pressures on a circular hyperbolic⁃paraboloid roof subjected to a simulated downburst [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(8): 1826-1833.
[4] Qing-lin GUO,Qiang LIU,Chun-li WU,Li-li LI,Yi-ming LI,Fu-chun LIU. Local temperature field and healing level of crack in conductive asphalt and mixture [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(6): 1386-1393.
[5] Quan-ping XIA,Jiang-ping GAO,Hao-yuan LUO,Qi-gong ZHANG,Zhi-jie LI,Fei YANG. Low⁃temperature performance of composite modified hard asphalt used in high modulus asphalt concrete [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(3): 541-549.
[6] Yong YAO,Liu-feng SU,Ming LI,Yun-peng CHU,Han-jie HUANG. Wind load characteristics of double⁃sided spherical shell roof under downburst [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(3): 615-625.
[7] Ya-chuan KUANG,Zhe-xuan SONG,Yin-hu LIU,Xiao-fei MO,Liang-ming FU,Shi-quan LUO. Experiment on mechanical properties of new type assembled double-cabin utility tunnel [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(3): 596-603.
[8] Zhi-yuan YUANZHOU,Bo-hai JI,Jun-yuan XIA,Tong SUN. Pneumatic impact test on rib⁃to⁃diaphragm fatigue crack of steel box girder [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(12): 2883-2891.
[9] Yi-hong WANG,Qiao-luo TIAN,Guan-qi LAN,Sheng-fa YAO,Jian-xiong ZHANG,Xi LIU. Experimental research on the mechanical properties of concrete column reinforced with 630 MPa high⁃strength steel under large eccentric loading [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(11): 2626-2635.
[10] Xiao-he YU,Rong LUO,Zi-yao LIU,Ting-ting HUANG,Yu SHU. Numerical simulation of humidity field of typical cracks in asphalt pavement [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(10): 2343-2351.
[11] Yong-zhi GONG,Jin-hua KUANG,Fu-long KE,Quan ZHOU,Xiao-yong LUO. Experiment on seismic behavior of assembled shear wall joints connected by ultra high performance concrete [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(10): 2367-2375.
[12] Xue-ping FAN,Guang-hong YANG,Zhi-peng SHANG,Xiao-xiong ZHAO,Qing-kai XIAO,Yue-fei LIU. Dynamic reliability fusion prediction of long-span bridge girder considering structural serviceability [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(1): 144-153.
[13] Fu-shou LIU,Qi WEI,Wen-ting XU,Guo-jin TAN. Damage detection of truss structures based on elastic wave propagation and spectral element method [J]. Journal of Jilin University(Engineering and Technology Edition), 2021, 51(6): 2087-2095.
[14] Ying-xin HUI,Xiao-rong SUN,Hong-yu WANG,Chen GAO. Effect of hydration heat temperature and cracking mechanism of beam end in early stage of T⁃beam [J]. Journal of Jilin University(Engineering and Technology Edition), 2021, 51(5): 1734-1741.
[15] Xue-ping FAN,Guang-hong YANG,Qing-kai XIAO,Yue-fei LIU. Optimal R-vine copula information fusion for failure probability analysis of long-span bridge girder [J]. Journal of Jilin University(Engineering and Technology Edition), 2021, 51(4): 1296-1305.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
Copyright © Journal of Jilin University(Engineering and Technology Edition), All Rights Reserved.
Tel: +86-431-85095297　Fax: +86-431-85094074　E-mail: xbgxb@jlu.edu.cn
Powered by Beijing Magtech Co. Ltd