Journal of Jilin University(Engineering and Technology Edition) ›› 2023, Vol. 53 ›› Issue (10): 2886-2896.doi: 10.13229/j.cnki.jdxbgxb.20220124

Previous Articles     Next Articles

Meso-scale numerical simulation of interfacial bond behavior of corroded RC beams based on connector element

Li-zhao DAI(),Liang ZHOU,Xiao-wen YANG,Lei WANG()   

  1. School of Civil Engineering，Changsha University of Science and Technology，Changsha 410114，China
  • Received:2022-01-26 Online:2023-10-01 Published:2023-12-13
  • Contact: Lei WANG E-mail:lizhaod@csust.edu.cn;leiwang@csust.edu.cn

RICH HTML

 2   

PDF (PC)

65

Abstract:

A three-dimensional meso-scale numerical model of corroded reinforced concrete（RC） beams was established by random aggregate model in the present study， and the connector element was used to capture the changes of interaction at the interface during loading. The rationality of the model was verified by experimental data. The interfacial bond-slip distribution and deformation coordination coefficient of corroded RC beams during the loading process were analyzed， and the effect of bond degradation on bearing capacity was discussed. Results show that the connector element can describe the bond stress and relative slip at the interface during the loading process， which is an effective method for simulating the interface behavior between corroded steel and concrete. The maximum bond stress at the interface decreases with increasing corrosion loss， a 30% of corrosion loss leads to a decrease of 71% in the maximum bond stress at the ultimate load. Corrosion can accelerate the relative slip at the interface of corroded RC beams， and the relative slip at the interface moves from the loading point position to the shear-flexure section. The ultimate deformation coordination coefficient at the interface decreases with the increase of corrosion loss. When the corrosion loss reaches 30%， the ultimate deformation coordination coefficient is 0.479， and the bearing capacity decreases by 55%.

Key words: structural engineering, corroded RC beams, bond-slip, deformation coordination coefficient, meso-scale numerical simulation

CLC Number: 

  • TU375.1

Fig.1

Three-dimensional meso-scale numerical model of RC beams"

Fig.2

Damage-fracture constitutive model of concrete"

Fig.3

Interface bond-slip constitutive model"

Fig.4

Connector element interface constraint behavior"

Fig.5

Damage response of connector element"

Table 1

Microscopic composition of concrete and mechanical parameters of steel materials"

参 数骨 料砂 浆ITZ主 筋箍筋及架立筋
弹性模量E/GPa70.032.530.0200.0200.0
泊松比ν0.20.20.20.30.3
抗拉强度ft/MPa/2.82.4//
抗压强度fc/MPa/36.530.5//
断裂能G/（J·m-2）/50.030.0//
剪胀角ψ/（°）/18.015.0//
屈服强度fy///376.0274.4
极限强度fu///551.9399.4

Fig.6

Simulation parameter verification and failure mode comparison"

Fig.7

Comparison of load-displacement curves between simulation and experiment"

Fig.8

Bond stress distribution and crack propagation"

Fig.9

Relative slip at interface between steel and concrete"

Fig.10

Deformation of Connector element and steel stress at interface"

Fig.11

Interfacial deformation coordination coefficientof corroded RC members under loading"

Fig.12

Fitting curve of ultimate deformation coordination coefficient"

Fig.13

Flexural strength of RC beams with differentcorrosion degrees"

1 王甲春, 阎培渝. 海洋环境下钢筋混凝土中钢筋锈蚀的概率[J]. 吉林大学学报:工学版, 2014, 44(2):352-357.
Wang Jia-chun, Yan Pei-yu. Probabilistic analysis of rebar rust in concrete under marine environment[J]. Journal of Jilin University (Engineering and Technology Edition), 2014, 44(2):352-357.
2 Hussein L. Analytical modeling of bond stress at steel-concrete interface due to corrosion[D]. Toronto: Ryerson University, 2011.
3 Pei P, Zheng S S, Zhang Y X, et al. Overview on the bonding of reinforced concrete under pristine, corrosive and freeze-thaw conditions[J]. Journal of Adhesion Science and Technology, 2019, 33(7): 761-789.
4 梁岩, 罗小勇, 肖小琼, 等. 锈蚀钢筋混凝土粘结滑移性能试验研究[J]. 工业建筑, 2012, 42(10):95-100.
Liang Yan, Luo Xiao-yong, Xiao Xiao-qiong, et al. Experimental study on bond-slip performance of corroded reinforced concrete[J]. Industrial Construction, 2012, 42(10):95-100.
5 Ma Y F, Guo Z Z, Wang L, et al. Experimental investigation of corrosion effect on bond behavior between reinforcing bar and concrete[J]. Construction and Building Materials, 2017, 152: 240-249.
6 Zhang X H, Wang L, Zhang J R, et al. Bond degradation-induced incompatible strain between steel bars and concrete in corroded RC beams[J]. Journal of Performance of Constructed Facilities, 2016, 30(6): No.04016058.
7 黄天立, 赵志彦, 宋力, 等. 纵筋锈蚀对钢筋混凝土梁抗剪性能影响的试验研究[J]. 中南大学学报:自然科学版, 2019, 50(8):1901-1911.
Huang Tian-li, Zhao Zhi-yan, Song Li, et al. Experimental investigation on shear performance of RC beams due to longitudinal reinforcement corrosion[J]. Journal of Central South University(Science and Technology), 2019, 50(8):1901-1911.
8 曹芙波, 尹润平, 王晨霞, 等. 锈蚀钢筋再生混凝土梁粘结性能及承载力研究[J]. 土木工程学报, 2016, 49():14-19.
Cao Fu-bo, Yin Run-ping, Wang Chen-xia, et al. Research on bond performance and bend strength of corroded reinforced recycled concrete beams[J]. China Civil Engineering Journal, 2016, 49(Sup.2):14-19.
9 薛昕, 杨成, 张瀚引, 等. 钢筋黏结退化的空间分布对RC梁受剪性能影响[J]. 华中科技大学学报:自然科学版, 2017, 45(1):11-16.
Xue Xin, Yang Cheng, Zhang Han-yin, et al. Influence of spatial distribution of bond deterioration in steel bar on shear performance of RC beams[J]. Journal of Huazhong University of Science and Technology(Natural Science Edition), 2017, 45(1):11-16.
10 Nilson A H. Nonlinear analysis of reinforced concrete by the finite element method[J]. Journal Proceedings, 1968,65(9): 757-766.
11 陈朝晖, 雷婷婷, 廖旻懋, 等. 基于内聚力模型的锈蚀砼梁抗弯刚度[J]. 重庆大学学报, 2017, 40(5):36-42.
Chen Zhao-hui, Lei Ting-ting, Liao Min-mao, et al. Numerical study on the stiffness of corroded beam based on the cohesive model[J]. Journal of Chongqing University, 2017, 40(5):36-42.
12 Xiong X Y, Xiao Q S. Meso-scale simulation of bond behaviour between retarded-bonded tendons and concrete[J]. Engineering Structures, 2021, 228:No. 111410.
13 Verwaerde R, Guidault P, Boucard P A. A non-linear finite element connector model with friction and plasticity for the simulation of bolted assemblies[J]. Finite Elements in Analysis and Design, 2021, 195: No.103586.
14 Zhao G Q. Etude expérimentale et numérique de la résistance à l'effondrement progressif de sous-assemblages poteaux-poutres en béton armé[D]. Grenoble: Université Grenoble Alpes (ComUE), 2019.
15 Li C Q, Yang S T, Saafi M. Numerical simulation of behavior of reinforced concrete structures considering corrosion effects on bonding[J]. Journal of Structural Engineering, 2014, 140(12): No.04014092.
16 Dai L Z, Long D X, Wang L. Meso-scale modeling of concrete cracking induced by 3D corrosion expansion of helical strands[J]. Computers & Structures, 2021, 254: No.106615.
17 Jin L, Wang T, Jiang X A, et al. Size effect in shear failure of RC beams with stirrups: simulation and formulation[J]. Engineering Structures, 2019, 199: No. 109573.
18 Wriggers P, Moftah S. Mesoscale models for concrete: Homogenisation and damage behaviour[J]. Finite Elements in Analysis and Design, 2006, 42(7): 623-636.
19 Song Z H, Lu Y. Mesoscopic analysis of concrete under excessively high strain rate compression and implications on interpretation of test data[J]. International Journal of Impact Engineering, 2012, 46: 41-55.
20 Lee J, Fenves G L. Plastic-damage model for cyclic loading of concrete structures[J]. Journal of Engineering Mechanics, 1998, 124(8): 892-900.
21 金浏, 陆凯, 宋博, 等. 考虑骨料粒径影响的BFRP筋混凝土梁剪切破坏及尺寸效应[EB/OL]. [2021-06-07].
22 金浏, 李炎锡, 张仁波, 等. 锈蚀钢筋混凝土柱偏心受压性能精细化模拟[EB/OL]. [2022-04-12].
23 Coronelli D, Gambarova P. Structural assessment of corroded reinforced concrete beams: modeling guidelines[J]. Journal of Structural Engineering, 2004, 130(8): 1214-1224.
24 Zandi Hanjari K, Kettil P, Lundgren K. Analysis of mechanical behavior of corroded reinforced concrete structures[J]. ACI Structural Journal, 2011, 108(5): 532-541.
25 .混凝土结构设计规范 [S].
26 Lee H S, Cho Y S. Evaluation of the mechanical properties of steel reinforcement embedded in concrete specimen as a function of the degree of reinforcement corrosion[J]. International Journal of Fracture, 2009, 157(1): 81-88.
27 Ma Y F, Zhang J R, Wang L, et al. Probabilistic prediction with Bayesian updating for strength degradation of RC bridge beams[J]. Structural Safety, 2013, 44: 102-109.
28 CEB-FIP. Model code [S].
29 狄生林. 钢筋混凝土梁的非线性有限元分析[J]. 东南大学学报:自然科学版, 1984, 24(2):87-96.
Di Sheng-lin. Nonlinear finite element analysis of reinforced concrete beam[J]. Journal of Southeast University(Natural Science Edition), 1984, 24(2):87-96.
[1] Xue-ping FAN,Heng ZHOU,Yue-fei LIU. Multi⁃process Bayesian dynamic combinatorial prediction of time⁃variant reliability for bridges [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(8): 2332-2338.
[2] Ya-na MAO,Shi-zhong LIU,Jian XING,Hua YANG,Yu-bo JIAO. Bond⁃slip characterization between ultra⁃high performance glass sand concrete and high⁃strength reinforcement based on acoustic emission parameters [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(6): 1686-1694.
[3] Ya-feng GONG,Shu-zheng WU,Hai-peng BI,Dong-ming ZHOU,Guo-jin TAN,Xiao-ming HUANG. Acoustic characterization of bond⁃slip process between basalt fiber reactive powder concrete and steel strand [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(6): 1819-1832.
[4] Er-gang XIONG,Zhong-wen GONG,Jia-ming LUO,Tuan-jie FAN. Experiment on cracks in reinforced concrete beams based on digital image correlation technology [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(4): 1094-1104.
[5] Ya-chuan KUANG,Li-bin CHEN,Chao-ju LI,Yu-hao HE. Analysis of mechanical properties of stud shear connectors [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(2): 538-546.
[6] Xiao-dong WANG,Ning-jing LI,Qiang LI. Experimental on crushing of concrete beams by high⁃voltage pulse discharge [J]. Journal of Jilin University(Engineering and Technology Edition), 2023, 53(2): 496-504.
[7] Yun-peng CHU,Xin-hui SUN,Ming LI,Yong YAO,Han-jie HUANG. Wind pressures on a circular hyperbolic⁃paraboloid roof subjected to a simulated downburst [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(8): 1826-1833.
[8] Yong YAO,Liu-feng SU,Ming LI,Yun-peng CHU,Han-jie HUANG. Wind load characteristics of double⁃sided spherical shell roof under downburst [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(3): 615-625.
[9] Ya-chuan KUANG,Zhe-xuan SONG,Yin-hu LIU,Xiao-fei MO,Liang-ming FU,Shi-quan LUO. Experiment on mechanical properties of new type assembled double-cabin utility tunnel [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(3): 596-603.
[10] Yi-hong WANG,Qiao-luo TIAN,Guan-qi LAN,Sheng-fa YAO,Jian-xiong ZHANG,Xi LIU. Experimental research on the mechanical properties of concrete column reinforced with 630 MPa high⁃strength steel under large eccentric loading [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(11): 2626-2635.
[11] Yong-zhi GONG,Jin-hua KUANG,Fu-long KE,Quan ZHOU,Xiao-yong LUO. Experiment on seismic behavior of assembled shear wall joints connected by ultra high performance concrete [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(10): 2367-2375.
[12] Xue-ping FAN,Guang-hong YANG,Zhi-peng SHANG,Xiao-xiong ZHAO,Qing-kai XIAO,Yue-fei LIU. Dynamic reliability fusion prediction of long-span bridge girder considering structural serviceability [J]. Journal of Jilin University(Engineering and Technology Edition), 2022, 52(1): 144-153.
[13] Fu-shou LIU,Qi WEI,Wen-ting XU,Guo-jin TAN. Damage detection of truss structures based on elastic wave propagation and spectral element method [J]. Journal of Jilin University(Engineering and Technology Edition), 2021, 51(6): 2087-2095.
[14] Xue-ping FAN,Guang-hong YANG,Qing-kai XIAO,Yue-fei LIU. Optimal R-vine copula information fusion for failure probability analysis of long-span bridge girder [J]. Journal of Jilin University(Engineering and Technology Edition), 2021, 51(4): 1296-1305.
[15] Jiang YU,Zhi-hao ZHAO,Yong-jun QIN. Damage of reinforced concrete shear beams based on acoustic emission and fractal [J]. Journal of Jilin University(Engineering and Technology Edition), 2021, 51(2): 620-630.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
Copyright © Journal of Jilin University(Engineering and Technology Edition), All Rights Reserved.
Tel: +86-431-85095297　Fax: +86-431-85094074　E-mail: xbgxb@jlu.edu.cn
Powered by Beijing Magtech Co. Ltd