吉林大学学报(工学版) ›› 2015, Vol. 45 ›› Issue (6): 1798-1803.doi: 10.13229/j.cnki.jdxbgxb201506010

• • 上一篇    下一篇

加载条件对车用发动机瞬态工况性能的影响

田径， 刘忠长， 张文杰， 张龙平   

  1. 吉林大学 汽车仿真与控制国家重点实验室,长春130022
  • 收稿日期:2014-06-08 出版日期:2015-11-01 发布日期:2015-11-01
  • 通讯作者: 刘忠长(1956-),男,教授,博士生导师.研究方向:内燃机公害与控制.E-mail:liuzc@jlu.edu.cn
  • 作者简介:田径(1981-),男,讲师,博士.研究方向:内燃机公害与控制.E-mail:jingtian@jlu.edu.cn
  • 基金资助:
    “973”国家重大基础研究发展计划项目(2013CB228402); 国家自然科学基金项目(51206060); 吉林省科技发展计划项目(20150520113JH)

Effect of load conditions on the performance of diesel engine under transient operation condition

TIAN Jing, LIU Zhong-chang, ZHANG Wen-jie, ZHANG Long-ping   

  1. State Key Laboratory of Automobile Simulation and Control, Jilin University, Changchun 130022, China
  • Received:2014-06-08 Online:2015-11-01 Published:2015-11-01

RICH HTML

0   

PDF (PC)

393

摘要： 在一台增压柴油机上探讨了恒转速、不同起始负荷以及相同加载范围下不同转速对发动机加载过程中燃烧及排放性能的影响。试验结果表明:在转速一定的条件下,相较于高怠速起始负荷的加载过程,起始负荷为部分负荷时加载过程中进气的响应性及缸内燃烧过程有一定程度的改善,碳烟排放量变化较小,而NOx的排放量变化较为明显,增幅变化是高怠速起始负荷NOx排放量的80%;转速不同的条件下,相较于高恒定转速,低恒定转速的瞬变过程中烟度的恶化程度急剧增大,NOx的改善程度提高。

关键词: 动力机械工程, 柴油机, 瞬态工况, 燃烧过程, 排放

Abstract: The performance of transient operating condition is different under different working conditions for turbocharged engine. The effects of different initial loads under constant engine speed, different engine speed with the same increasing torque process on engine combustion process and emissions were investigated on a turbocharged diesel engine. The results indicate that, compared with high idle increasing torque, initial load as partial load has improving effect on the responsiveness of air intake and combustion process at constant speed and the smoke opacity varies slightly. However, the change of NOx is significant, which is about 80% more than that of high idle initial load with constant speed and increasing torque. Results also show that for different speed conditions, compared with high constant speed in transient combustion process, the deterioration of smoke opacity is worse and the improvement of NOx emission is enhanced at low constant speed.

Key words: dynamic mechanical engineering, diesel engine, transient operating condition, combustion, emission

中图分类号: 

  • TK421.2
[1] Nilsson T, Froberg A, Aslund J. Optimal operation of a turbocharged diesel engine during transients[C]∥SAE Paper,2012-01-0711.
[2] Han Y Q, Liu Z C, Liu X M. Effect of combustion parameters on diesel engine smoke opacity under constant speed and increasing torque transient operating condition[J]. Journal of Combustion Science and Technology,2004,10(1):23-27.
[3] Yokomura H, Kouketsu S, Kotooka S,et al.Transient EGR control for a turbocharged heavy duty diesel engine[C]∥SAE Paper, 2004-01-0120.
[4] Kang H, Farrell P V. Experimental investigation of transient emissions(HC and NO x ) in a high-speed direct injection(HSDI) diesel engine[C]∥SAE Paper, 2005-01-3883.
[5] Tufail K, Winstanley T, Karagi-orgis S, et al. Characterisation of diesel engine transient pumping loss and control methodology for transient specific fuel consumption (SFC)[C]∥SAE Paper,2009-01-2748.
[6] Millo F, Pautasso E, Pasero P, et al. An experimental and numerical study of an advanced EGR control system for automotive diesel engine[C]∥SAE Paper,2008-01-0208.
[7] Malikopoulos A A, Assanis D N, Papalambros P Y. Real time self-learning optimization of diesel engine calibration[J]. Journal of Engineering for Gas Turbines and Power,2009,131(2):022803.
[8] Serrano J R, Arnau F J, Dolz V, et al. Analysis of the capabilities of a two-stage turbocharging system to fulfil the US2007 anti-pollution directive for heavy duty diesel engines[J]. International Journal of Automotive Technology,2008,9(3):277-288.
[9] Han Yong-qiang,Liu Zhong-chang, Wang Zhong-shu,et al. HPAS control strategies and their effects on diesel engine under transient operations[J]. Transactions of CSICE,2006,24(6):513-517.
[10] 许允,刘江唯,刘忠长,等. 车用直喷柴油机瞬态工况控制及微粒排放测量[J]. 燃烧科学与技术,2003,9(1):88-92.
Xu Yun,Liu Jiang-wei,Liu Zhong-chang,et al. Control and exhaust particulate measurement of automotive DI diesel engine under transient operating conditions[J]. Journal of Combustion Science and Technology,2003,9(1):88-92.
[11] 张龙平,刘忠长,田径,等. 柴油机瞬变工况的动态响应及燃烧劣变分析[J]. 内燃机学报,2014,32(2):104-110.
Zhang Long-ping, Liu Zhong-chang, Tian Jing, et al. Dynamic response and combustion deterioration analysis of a diesel engine under transient operations[J]. Transactions of CSICE, 2014,32(2):104-110.
[1] 董伟,宋佰达,邱立涛,孙昊天,孙平,蒲超杰. 直喷汽油机暖机过程中两次喷射比例对燃烧和排放的影响[J]. 吉林大学学报(工学版), 2018, 48(6): 1755-1761.
[2] 林学东, 江涛, 许涛, 李德刚, 郭亮. 高压共轨柴油机起动工况高压泵控制策略[J]. 吉林大学学报(工学版), 2018, 48(5): 1436-1443.
[3] 杨帅, 冯志炜, 赵治国, 周毅. 不同米勒循环方式对柴油机工作过程影响的一维模拟分析[J]. 吉林大学学报(工学版), 2018, 48(5): 1444-1454.
[4] 李志军, 汪昊, 何丽, 曹丽娟, 张玉池, 赵新顺. 催化型微粒捕集器碳烟分布及其影响因素[J]. 吉林大学学报(工学版), 2018, 48(5): 1466-1474.
[5] 秦静, 徐鹤, 裴毅强, 左子农, 卢莉莉. 初始温度和初始压力对甲烷-甲醇裂解气预混层流燃烧特性的影响[J]. 吉林大学学报(工学版), 2018, 48(5): 1475-1482.
[6] 宫洵, 蒋冰晶, 胡云峰, 曲婷, 陈虹. 柴油机主-从双微元Urea-SCR系统非线性状态观测器设计与分析[J]. 吉林大学学报(工学版), 2018, 48(4): 1055-1062.
[7] 钟兵, 洪伟, 金兆辉, 苏岩, 解方喜, 张富伟. 进气门早关液压可变气门机构运动特性[J]. 吉林大学学报(工学版), 2018, 48(3): 727-734.
[8] 席雷, 徐亮, 高建民, 赵振, 王明森. 厚壁矩形带肋通道内蒸汽流动及传热特性[J]. 吉林大学学报(工学版), 2018, 48(3): 752-759.
[9] 李龙, 张幽彤, 左正兴. 变负载控制在自由活塞内燃发电机的缸压控制中的应用[J]. 吉林大学学报(工学版), 2018, 48(2): 473-479.
[10] 田径, 刘忠长, 刘金山, 董春晓, 钟铭, 杜文畅. 基于燃烧边界参数响应曲面设计的柴油机性能优化[J]. 吉林大学学报(工学版), 2018, 48(1): 159-165.
[11] 卫海桥, 裴自刚, 冯登全, 潘家营, 潘明章. 压电喷油器多次喷射对GDI汽油机颗粒物排放的影响[J]. 吉林大学学报(工学版), 2018, 48(1): 166-173.
[12] 李志军, 何丽, 姜瑞, 申博玺, 孔祥金, 刘世宇. 柴油机微粒捕集器灰分分布对其压降的影响评价[J]. 吉林大学学报(工学版), 2017, 47(6): 1760-1766.
[13] 郭亮, 杨文昭, 王云开, 孙万臣, 程鹏, 李国良. 废气再循环对丁醇/柴油混合燃料发动机的影响[J]. 吉林大学学报(工学版), 2017, 47(6): 1767-1774.
[14] 虞浏, 刘忠长, 刘江唯, 杜宏飞, 许允. 直喷汽油机喷雾粒径特性[J]. 吉林大学学报(工学版), 2017, 47(5): 1482-1488.
[15] 刘忠长, 腾鹏坤, 田径, 许允, 亓升林, 于凯波. 二级增压柴油机旁通阀调节特性[J]. 吉林大学学报(工学版), 2017, 47(3): 796-803.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 《吉林大学学报(工学版)》编辑部
地址：长春市人民大街5988号　电话：+86-431-85095297　传真：+86-431-85094074　E-mail: xbgxb@jlu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发