吉林大学学报(工学版) ›› 2014, Vol. 44 ›› Issue (5): 1531-1536.doi: 10.7964/jdxbgxb201405048

• • 上一篇    

蛋白质用量和比例对淡奶油理化性质的影响

赵谋明, 龙肇, 赵强忠, 徐巨才   

  1. 华南理工大学 轻工与食品学院, 广州 510640
  • 收稿日期:2013-02-22 出版日期:2014-09-01 发布日期:2014-09-01
  • 作者简介:赵谋明(1964), 男, 教授, 博士生导师.研究方向:食品生物技术, 蛋白质化学与工程及食品乳浊体系.E-mail:femmzhao@scut.edu.cn
  • 基金资助:
    国家自然科学基金项目(20806030,31171783).

Effects of protein content and composition on the physicochemical properties of whipping cream

ZHAO Mou-ming,LONG Zhao,ZHAO Qiang-zhong,XU Ju-cai   

  1. College of Light Industry and Food Science, South China University of Technology, Guangzhou 510640, China
  • Received:2013-02-22 Online:2014-09-01 Published:2014-09-01

RICH HTML

0   

PDF (PC)

444

摘要： 研究了酪朊酸钠用量及质量分数为3%的蛋白质用量下酪朊酸钠和大豆分离蛋白不同比例对淡奶油粒度分布、界面蛋白及流变学特性的影响,分析了其作用机理。结果表明:随着酪朊酸钠体积分数的增加,淡奶油上层粒径先减小后增大,在4%处达最小值,峰值为0.18 μm,黏度和屈服应力增大,界面蛋白含量升高,界面蛋白浓度先减小后增大,剪切稀化程度先增强后减弱;蛋白质总用量为3%时,增加大豆分离蛋白比例,样品粒度增大,界面蛋白质量分数由2.96%降至2.56%,剪切速率为60 s-1时黏度由0.154 Pa·s增加至0.297 Pa·s,屈服应力增大,剪切稀化加剧。

关键词: 食品加工技术, 淡奶油, 流变特性, 酪朊酸钠, 界面蛋白, 大豆分离蛋白

Abstract: The effects of sodium caseinate content and proportion of sodium caseinate and soy protein on the droplet size distribution, surface protein and rheological properties of whipping cream were studied, and the possible mechanisms were also analyzed. Results show that with the increase in sodium caseinate, the particle size at the top cream decreases first and then increases, and sample of 4% gets the minimum value. The apparent viscosity, yield stress and surface protein content increase, while surface protein concentration increases first and then decreases; the shear-thinning characteristic is also improved first and then weakened. As the total protein content is fixed at 3%, with the increase in soy protein isolate ratio, the droplet size and yield stress increase, the shear-thinning characteristic is improved and the surface protein content decreases from 2.96% to 2.56%, the apparent viscosity increases from 0.154 Pa·s to 0.297 Pa·s at the shear rate of 60 s-1.

Key words: food processing technology, whipping cream, rheological properties, sodium caseinate, surface protein, soy protein isolate

中图分类号: 

  • TS252
[1] Zhao Q Z, Zhao M M, Li J R, et al. Effect of hydroxypropyl methylcellulose on the textural and whipping properties of whipped cream[J]. Food Hydrocolloids, 2009,23(8): 2168-2173.
[2] Kovác∨ová R, tětina J, C∨urda L. Influence of processing and k-carrageenan on properties of whipping cream[J]. Journal of Food Engineering, 2010, 99(4): 471-478.
[3] 赵强忠.搅打稀奶油的搅打性能和品质的变化规律及其机理研究[D]. 广州:华南理工大学轻工与食品学院, 2006.Zhao Qiang-zhong. Change and mechanism of whipping properties and qualities of whipped cream[D]. Guangzhou: College of Light Industry and Food Science, South China University and Technology, 2006.
[4] Rouimi S, Schorsch C, Valentini C, et al. Form stability and interfacial properties of milk protein-surfactant systems[J]. Food Hydrocolloids, 2005, 19(3): 467-478.
[5] Long Z, Zhao M M, Zhao Q Z, et al. Effect of homogenisation and storage time on surface and rheology properties of whipping cream[J]. Food Chemistry, 2012, 131(3):748-753.
[6] Aiqian Y. Functional properties of milk protein concentrates: emulsifying properties, adsorption and stability of emulsions[J]. International Dairy Journal, 2011, 21(1): 14-20.
[7] Roesch R R, Corredig M. Texture and microstructure of emulsions prepared with soy protein concentrate by highpressure homogenization[J]. LWT-Food Science and Technology, 2003, 36(1): 113-124.
[8] Palanuwech J, Coupland J N. Effect of surfactant type on the stability of oil-in-water eulsions to dispersed phase crystallization[J]. Colloids and Surfaces A, 2003, 223(1-3): 251-262.
[9] Heffernan S P, Kelly A L, Mulvihill D M. High-pressure-homogenised cream liqueurs: emulsification and stabilization efficiency[J]. Journal of Food Engineering, 2009, 95(3): 525-531.
[10] Quemada D. Rheology of concentrated disperse systems. II. A model for non-Newtonian shear viscosity in steady flows[J]. Rheologica Acta, 1978, 17(6): 632-642.
[11] Dickinson E. Milk protein interfacial layer and the relationship to emulsion stability and rheology[J]. Colloids and Surfaces B, 2001, 20(3): 197-210.
[12] Dickinson E, Golding M. Depletion flocculation of emulsions containing unadsorbed sodium caseinates[J]. Food Hydrocolloids, 1997, 11(1): 13-18.
[1] 念腾飞, 李萍, 林梅. 冻融循环下沥青特征官能团含量与流变参数灰熵分析及微观形貌[J]. 吉林大学学报(工学版), 2018, 48(4): 1045-1054.
[2] 徐梦蕾, 高宇, 刘静波, 熊晋锋, 赵颂宁, 黄延军. 基于抗氧化的大豆异黄酮对PC12细胞的神经保护作用[J]. 吉林大学学报(工学版), 2017, 47(1): 332-336.
[3] 张铁华, 姜楠, 刘迪茹, 郝锦峰, 毛春玲, 郭明若. 乳清蛋白基质脂肪替代物的制备及其在低脂液态奶中的应用效果[J]. 吉林大学学报(工学版), 2015, 45(3): 1024-1028.
[4] 袁媛, 张焕杰, 苗雨田, 吴思佳, 林松毅, 刘静波. 鲜切薯片油炸过程中丙烯酰胺形成的贡献率[J]. 吉林大学学报(工学版), 2014, 44(5): 1525-1530.
[5] 金声琅, 王莹, 殷涌光. 高压脉冲电场对淀粉和肌原纤维蛋白混合凝胶强度的影响[J]. 吉林大学学报(工学版), 2014, 44(2): 573-578.
[6] 徐艳阳, 蔡森森, 吴海成. 玉米热风与微波联合干燥特性[J]. 吉林大学学报(工学版), 2014, 44(2): 579-584.
[7] 张铁华, 李玺, 叶海青, 车宇飞, 田路, 于亚莉. 发酵林蛙油饮品的研制及工艺优化[J]. 吉林大学学报(工学版), 2013, 43(06): 1719-1724.
[8] 王利民, 肖志刚, 刘宇欣, 李杰, 孙旭, 申勋业, 李佳栋. 响应面法优化板栗基营养米挤压加工参数[J]. 吉林大学学报(工学版), 2013, 43(02): 550-556.
[9] 刘静波, 常皓, 王二雷, 宫新统, 姜轶群. 高效液相色谱法检测蛋黄卵磷脂中的磷脂酰胆碱[J]. 吉林大学学报(工学版), 2012, 42(增刊1): 449-453.
[10] 马中苏, 高宇芃, 牛彦清, 陈珊珊. 大豆分离蛋白/壳聚糖共混膜热力学性能[J]. 吉林大学学报(工学版), 2012, 42(增刊1): 470-474.
[11] 刘静波, 陶旭, 姜玮, 丁龙, 王二雷. 利用二次回归正交旋转组合设计优化鸡蛋壳膜唾液酸提取工艺[J]. , 2012, 42(04): 1071-1076.
[12] 孙钟雷, 孙永海, 李宇, 刘晶晶. 基于仿齿压头的物料脆裂力学模型建立及验证[J]. 吉林大学学报(工学版), 2012, 42(02): 510-514.
[13] 赵文竹, 殷涌光, 于志鹏, 于一丁, 刘静波. 玉米须多糖微波提取工艺及其红外光谱结构分析[J]. 吉林大学学报(工学版), 2012, 42(02): 515-520.
[14] 刘静波, 王菲, 王翠娜, 刘军, 王作昭, 王二雷, 张燕, 林松毅. Alcalase酶解蛋清粉制备抗凝血肽的工艺优化[J]. 吉林大学学报(工学版), 2012, 42(01): 250-255.
[15] 庄红, 陈乐群, 张婷, 朱媛媛, 唐宁, 袁媛. 亚铁血红素肽复合型保护剂的性能[J]. 吉林大学学报(工学版), 2012, 42(01): 256-260.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 《吉林大学学报(工学版)》编辑部
地址：长春市人民大街5988号　电话：+86-431-85095297　传真：+86-431-85094074　E-mail: xbgxb@jlu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发