吉林大学学报(工学版) ›› 2026, Vol. 56 ›› Issue (2): 333-344.doi: 10.13229/j.cnki.jdxbgxb.20240837

• 车辆工程·机械工程 • 上一篇    

变海拔下柴油机颗粒捕集器及灰分对柴油机瞬态特性的影响

陈贵升1(),金纳俊哲1,罗国焱1,龚航2(),杨森1,彭益源3   

  1. 1.昆明理工大学 云南省内燃机重点实验室,昆明 650500
    2.昆明理工大学 工程训练中心,昆明 650500
    3.云南菲尔特环保科技有限公司,昆明 650300
  • 收稿日期:2024-07-24 出版日期:2026-02-01 发布日期:2026-03-17
  • 通讯作者: 龚航 E-mail:cgs_yly@163.com;834319423@qq.com
  • 作者简介:陈贵升(1979-),男,教授,博士. 研究方向:内燃机排放与控制. E-mail: cgs_yly@163.com
  • 基金资助:
    云南省基础研究计划重点项目(202401AS070102);大学生创新创业计划项目(S202210674147)

Effects of altitude variation on diesel engine transient characteristics with consideration of particulate filters and ash

Gui-sheng CHEN1(),Na-jun-zhe JIN1,Guo-yan LUO1,Hang GONG2(),Sen YANG1,Yi-yuan PENG3   

  1. 1.Yunnan Key Laboratory of Internal Combustion Engine,Kunming University of Science and Technology,Kunming 650500,China
    2.Engineering Training Centre,Kunming University of Science and Technology,Kunming 650500,China
    3.Yunnan Filter Environment Protection Science & Technology Corporation Limited,Kunming 650300,China
  • Received:2024-07-24 Online:2026-02-01 Published:2026-03-17
  • Contact: Hang GONG E-mail:cgs_yly@163.com;834319423@qq.com

摘要:

基于GT-Power搭建耦合柴油机颗粒捕集器(DPF)的国六柴油机一维瞬态模型,探讨了变海拔下DPF对柴油机恒转速变扭矩瞬态特性的影响,并研究了灰分层渗透率变化对柴油机瞬态性能及DPF工作特性的影响,同时对DPF载体配比及直径范围进行了优化。结果显示,DPF会导致柴油机瞬态进气流量、扭矩和热效率低于原机,燃油消耗率则高于原机,在高海拔及恒转速增扭矩工况后期尤为明显。钙基灰分对瞬态特性的影响最大,在变海拔恒转速增扭矩工况后期,镁基和锌基灰分会导致DPF压降出现转折。当载体配比超过1.2和载体直径大于190 mm时,DPF对附加燃油消耗率的影响趋于平缓,碳载量的增加会加剧这一趋势。

关键词: 动力机械工程, 柴油机颗粒物捕集器, 国六柴油机, 瞬态特性, 灰分

Abstract:

A one-dimensional transient model of a China VI diesel engine equipped with a diesel particulate filter (DPF) was developed using GT-Power. This study explores the effects of DPF on diesel engine transient characteristics under varying altitudes, specifically focusing on constant-speed, varying-torque scenarios. It also examines how changes in ash layer permeability impact engine transient performance and DPF operation, while optimizing the DPF substrate ratio and diameter range. The results show that the DPF reduces transient intake flow, torque, and thermal efficiency compared to the original engine, while increasing fuel consumption, particularly at high altitudes and in the later stages of constant-speed, increasing-torque conditions. Calcium-based ash has the most significant impact on transient characteristics. During the later stages of these conditions under varying altitudes, magnesium- and zinc-based ash cause a shift in DPF pressure drop. When the substrate ratio exceeds 1.2 and the substrate diameter exceeds 190 mm, the impact on additional fuel consumption stabilizes, although increased carbon loading intensifies this trend.

Key words: power machinery and engineering, diesel particulate filter (DPF), China VI diesel engine, transient characteristicse, ash

中图分类号: 

  • TK422

图1

DPF压降组成图"

表1

发动机主要技术参数"

名 称参 数
发动机机型直列4缸
燃油喷射系统电控高压共轨系统
进气形式增压中冷
压缩比16.60
排量/L2.97
额定功率/kW125/(2 800 r·min-1
最大转矩/(N·m)500/(1 200~2 200 r·min-1

表2

DPF技术参数"

名称参数
材质碳化硅
直径/in7.5
长度/in5
孔密度/cpsi300
体积/L3.62
壁厚/mil10
配比/%1.22

图2

恒转速增扭矩工况试验值和模拟值对比"

图3

恒转速减扭矩工况试验值和模拟值对比"

图4

恒转速增扭矩下对柴油机性能的影响"

图5

恒转速减扭矩下对柴油机性能的影响"

表3

不同润滑油添加剂形成的灰分层渗透率[17]"

灰分层类型润滑油添加剂灰分层渗透率/m2
Ca基灰分层Ca基润滑油1.67×10-14
Zn基灰分层Zn基润滑油8.56×10-14
Mg基灰分层Mg基润滑油5.74×10-13

图6

恒转速增扭矩下灰分层渗透率对柴油机性能的影响"

图7

恒转速减扭矩下灰分层渗透率对柴油机性能的影响"

图8

恒转速增扭矩下DPF壁厚对DPF压降的影响"

图9

恒转速减扭矩下DPF壁厚对DPF压降的影响"

图10

恒转速增扭矩下灰分层渗透率对DPF压降的影响"

图11

恒转速减扭矩下灰分层渗透率对DPF压降的影响"

表4

不同DPF配比载体参数"

参数配比
1.11.21.351.441.53
直径/mm143.8190.5170.2190.5170.2
载体长度/mm203.2127.0177.8152.4203.2
载体体积/L3.303.604.054.344.60
总灰分量/g0/300/300/300/300/30
总碳载量/g0/180/180/180/180/18

图12

不同海拔下载体配比对附加燃油消耗率的影响"

图13

不同海拔下载体直径对附加燃油消耗率的影响"

[1] Meng Z, Chen C, Li J, et al. Particle emission characteristics of DPF regeneration from DPF regeneration bench and diesel engine bench measurements[J]. Fuel, 2020, 262: No.116589.
[2] 张韦, 陈朝辉, 孔孟茜, 等. 柴油机催化型颗粒捕集器喷油助燃再生特征[J]. 农业工程学报, 2019, 35(8): 92-99.
Zhang Wei, Chen Zhao-hui, Kong Meng-qian, et al. Diesel engine catalytic particle trap injection combustion regeneration characteristics[J]. Transactions of the Chinese Society of Agricultural Engineering, 2019, 35(8): 92-99.
[3] Yamamoto K, Sakai T. Simulation of continuously regenerating trap with catalyzed DPF[J]. Catalysis Today, 2015, 242: 357-362.
[4] Han Y, Zhang L, Liu Z, et al. Investigation of transient deterioration mechanism and improved method for turbocharged diesel engine[J]. Energy, 2016, 116: 250-264.
[5] 杨凯, 霍柏琦, 姚晔, 等. 船用大功率柴油机瞬态工况油气响应及燃烧特性研究[J]. 推进技术, 2022, 43(8): 410-415.
Yang Kai, Huo Bo-qi, Yao Ye, et al. Oil and gas response and combustion characteristics of marine high power diesel engine under transient conditions[J]. Journal of Propulsion Technology, 2022, 43(8): 410-415.
[6] Rakopoulos C D, Dimaratos A M, Giakoumis E G, et al. Exhaust emissions estimation during transient turbocharged diesel engine operation using a two-zone combustion model[J]. International Journal of Vehicle Design, 2009, 49(1-3): 125-149.
[7] Yum K K, Lefebvre N, Pedersen E. An experimental investigation of the effects of cyclic transient loads on a turbocharged diesel engine[J]. Applied Energy, 2017, 185: 472-481.
[8] Liu Z C, Yu K B, Tian J, et al. Influence of rail pressure on a two-stage turbocharged heavy-duty diesel engine under transient operation[J]. International Journal of Automotive Technology, 2017, 18(1): 19-29.
[9] 陈贵升, 李青, 陈春林, 等. 灰分沉积对不同结构CDPF再生特性的影响[J]. 汽车工程, 2020, 42(6): 725-733.
Chen Gui-sheng, Li Qing, Chen Chun-lin, et al. Effect of ash deposition on the regeneration properties of CDPF with different structures[J]. Automotive Engineering, 2020, 42(6): 725-733.
[10] 李志军, 何丽, 姜瑞, 等. 柴油机微粒捕集器灰分分布对其压降的影响评价[J]. 吉林大学学报:工学版, 2017, 47(6): 1760-1766.
Li Zhi-jun, He Li, Jiang Rui, et al. Evaluation of influence of ash distribution on diesel particulate filter pressure drop[J]. Journal of Jilin University(Engineering and Technology Edition), 2017, 47(6): 1760-1766.
[11] 张俊, 帅石金, 肖建华. 灰分对柴油机颗粒捕集器性能影响研究综述[J]. 内燃机工程, 2018, 39(6): 11-23.
Zhang Jun, Shi-jin Shuai, Xiao Jian-hua. A review of ash effects on DPF performance[J]. Chinese Internal Combustion Engine Engineering, 2018, 39(6): 11-23.
[12] 蒲云飞, 孟忠伟. DPF内颗粒沉积特性分析[J]. 小型内燃机与车辆技术, 2018, 47(5): 92-96.
Pu Yun-fei, Meng Zhong-wei. Analysis of particulate deposition characteristics in the DPF[J]. Small Internal Combustion Engine and Motorcycle, 2018, 47(5): 92-96.
[13] Sappok A, Munnis S, Wong V W. Individual and synergistic effects of lubricant additive components on diesel particulate filter ash accumulation and performance[C]∥ Internal Combustion Engine Division Spring Technical Conferenc, Torino, Italy, 2012: 531-546.
[14] Gurel C, Ozmen E, Yilmaz M, et al. Multi-objective optimization of transient air-fuel ratio limitation of a diesel engine using DoE based Pareto-optimal approach[J]. SAE International Journal of Commercial Vehicles, 2017, 10: 299-307.
[15] Hu B, Yang J, Li J, et al. Intelligent control strategy for transient response of a variable geometry turbocharger system based on deep reinforcement learning[J]. Processes, 2019, 7(9): 601.
[16] 孙万臣, 刘高, 郭亮, 等. 微粒捕集器对高压共轨柴油机超细微粒捕集特性[J]. 吉林大学学报:工学版, 2016, 46(1): 133-139.
Sun Wan-chen, Liu Gao, Guo Liang, et al. Efficiency of DPF on ultrafine particles in a common-rail diesel engine[J]. Journal of Jilin University(Engineering and Technology Edition), 2016, 46(1): 133-139.
[17] Wang Y, Wong V, Sappok A, et al. The sensitivity of DPF performance to the spatial distribution of ash inside DPF inlet channels[C]∥ SAE Technical Paper, Detroit, America, 2013:No.2013011584.
[1] 王建,马文虎,谢太林,郭华,尹必峰. 重型拖拉机新型双离合全动力换挡变速箱液压系统设计与试验[J]. 吉林大学学报(工学版), 2025, 55(5): 1806-1816.
[2] 熊勇,田杰,程勇,赵庆武. 放电参数对NH3/空气混合气纳秒脉冲多通道点火特性的影响[J]. 吉林大学学报(工学版), 2025, 55(12): 3783-3792.
[3] 陈艳玲,郭亮,王会,孙万臣,李德刚,宣熔. 不同壁面特性下燃料喷雾的撞壁过程[J]. 吉林大学学报(工学版), 2025, 55(10): 3089-3099.
[4] 商蕾,杨萍,杨祥国,潘建欣,杨军,张梦如. 基于APSO-BP-PID控制的质子交换膜燃料电池热管理系统温度控制[J]. 吉林大学学报(工学版), 2024, 54(9): 2401-2413.
[5] 张帆,韩宁,杜青,部竞琦,彭志军. MMH凝胶液滴蒸发与燃烧过程的数值仿真[J]. 吉林大学学报(工学版), 2024, 54(11): 3114-3124.
[6] 魏明亮,李志丹,田波,李青,颜伏伍,王宇. 长径比对颗粒物捕集器压降交点及内部流场的影响[J]. 吉林大学学报(工学版), 2024, 54(11): 3125-3134.
[7] 陈贵升,罗国焱,李靓雪,黄震,李一. 柴油机颗粒捕集器孔道流场及其高原环境下噪声特性分析[J]. 吉林大学学报(工学版), 2023, 53(7): 1892-1901.
[8] 王建,于威,王斌. 高原状态下甲醇替代率对柴油机燃烧与排放的影响[J]. 吉林大学学报(工学版), 2023, 53(4): 954-963.
[9] 金兆辉,谷乐祺,洪伟,解方喜,尤田. 液压可变气门系统压力波动的影响分析[J]. 吉林大学学报(工学版), 2022, 52(4): 773-780.
[10] 张岩,刘玮,张树勇,裴毅强,董蒙蒙,秦静. 二/四冲程可变柴油机燃烧室热负荷的改善[J]. 吉林大学学报(工学版), 2022, 52(3): 504-514.
[11] 汤东,韩宇彬,华伦,潘金冲,刘胜. 润滑油灰分对直喷汽油机颗粒捕集器性能影响[J]. 吉林大学学报(工学版), 2022, 52(11): 2501-2507.
[12] 赵文伯,李玉洁,邓俊,李理光,吴志军. 针阀运动规律及其对喷嘴内流和喷雾特性影响[J]. 吉林大学学报(工学版), 2022, 52(10): 2234-2243.
[13] 李志军,刘浩,张立鹏,李振国,邵元凯,李智洋. 过滤壁结构对颗粒捕集器深床过滤影响的模拟[J]. 吉林大学学报(工学版), 2021, 51(2): 422-434.
[14] 赵庆武,程勇,杨雪,王宁. 高重频纳秒脉冲放电点火系统设计[J]. 吉林大学学报(工学版), 2021, 51(2): 414-421.
[15] 王忠,李游,张美娟,刘帅,李瑞娜,赵怀北. 柴油机排气阶段颗粒碰撞过程动力学特征分析[J]. 吉林大学学报(工学版), 2021, 51(1): 39-48.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!